Jump to content
Nugget Shooter Forums

My Fantasy Prospecting Vehicle


Recommended Posts

post-22152-127544912598_thumb.jpg

Cab

 Upgraded cab - leather & wood trim, additional insulation

 SS fire extinguisher at floor on left side of driver seat

 Seats - adjustable air suspension front

 Cab rear suspension air bag type

 Power windows & doors w/remote control

 Full gauges & instrumentation

 Cobra CB radio

 Alpine CDA-9857 AM FM XM CD Ipod stereo system

 GPS – Garmin 7500 w/rear view camera and weather fax

Chassis

 International 7400 4x4

 Extended cab - Overall length – 372”, width – 98”, height – 144”

 GVWR – 33,000 lb, GCVWR - 80,000 lb

 Wheelbase – 213” (5410 mm), cab-to-axle – 112”, axle-to-frame – 75”

 Frame rails – heat treated alloy steel 120,000 lb psi, 10.866” X 3.622” X 0.433” (276mm X 92mm X 11.1mm)

 DT570 50-state, 310 hp, 950 lb-ft torque @ 1200 rpm, #2 bell housing

 8 mpg @ 60 mph

 Chassis batteries – 2 X 210 ah AGM marine

 Supplemental alternator – 90a with I-U charging regulator for body

 Engine block heater – Phillips 120v/1250w, located below driver’s door

 Air compressor – Bendix TU-FLO 550, 13.2 cf quick connects front and rear

 Allison 3000 RDS P close ratio, 6-speed w/overdrive

 Transfer case – Meritor T-4210, 2-speed, 10,000 lb w/provision for PTO

 All wheel drive, engageable

 Front axle - Meritor MX-12-120 single reduction, 12,000 lb

 Rear axle - Meritor RS-21-145 single reduction, wide track, 21,000 lb w/driver controlled main locking differential, 200 series wheel ends and ABS gear ratio: 5.13

 Air brake ABS – Bendix antilock brake system, 4-channel

 Front brakes – air cam, S-cam, 16.5” X 5.0” inc 20 sq in MGM long stroke brake chambers

 Rear brakes – air cam 16.5” X 7.0” inc MGM TR3030 long stroke brake chamber and HD spring actuated parking brake

 Exhaust brake – D Logic, electronically activated

 Air dryer – Bendix AD-IP with heater

 Alcoa 22.5” aluminium wheels

 Michellin XZL 445/65R22.5

 Fuel tanks – 2 X 120 gal w/ 9mm skid plates (approximately 2,000 mi range)

 Racor fuel prefilters w/ water separators/heaters

 SS roof rack – in-motion TV antenna, generator cooling system, work lights, and 4 X Hella 2100 HID lights

 SS wire mesh head lights brush & stone guards

 Winches – hydraulic 15,000 lb front & rear w/15 gal reservoir and PTO pump

 Rear bumper - SS fold-down under-ride protection

 Water fording - all breather tubes raised to minimum 5’, positive pressure in generator compartment, sealed storage compartments

 Generator – 8kw Fischer Panda

 Spare - rear mounted w/manual hoist

 Rear rack – manual hoist, adaptable for storage, inflatable boat/outboard, bicycles or motorcycle

Body Unit

Frame assembly

 3-point kinematic attachment with main and flex mounts for stress-free body coupling to the torsion elastic chassis frame

Body unit construction

 Body dimensions – length 205” X width 98” X height 83”

 Self-supporting UNICAT sandwich panels of fiberglass composite

 Panel connections made by adhesive bond to custom extrusions eliminates metallic heat conduction paths

 Matched thermal coefficients of expansion prevent distortion with changes in temperature

 Wall thickness 2.36" ( 60 mm ) with polyurethane foam insulation, 0.12" ( 3 mm ) FRP outer surface, 0.08" ( 2 mm ) FRP inner surface

 Insulation rating 0.078 btu/ft h degF ( 0.44 W/sqm K )

 Floor panel with integrated welded steel frame and surfaces of fiberglass reinforced polyester

 Teak flooring

Access to body

 Cab-to-body passage – 23” X 32” w/solid & soft panels

 Highly flexible waterproof bellows coupling

 Access to body – hydraulic stairs, 3 control locations

Entrance door and storage compartment doors

 UNICAT - entrance door and storage doors constructed of fiberglass composite panels and frames, 3-point stainless steel safety locks, mosquito net at entry door

 Thickness of doors 2.36" ( 60 mm )

 UNICAT double seals with heavy duty lock

 Stainless steel hinges throughout

 Additional retractable bolts at middle, top and bottom of doors

 Safety cylinder locks all keyed alike

Windows

 Burglar-proof, scratchproof windows with thermal insulated aluminum frames

 Double insulated thermal window glass

 Shutters and mosquito nets

Interior Lay Out

Inner dimensions of the cabin

 Length 200" ( 5080 mm )

 Width 92.9" ( 2360 mm )

 Height 76.8" ( 1950 mm )

Seating area

 Seating area for 2 - 4 people with adjustable swiveling table on pedestal in the front of the cabin

 Seating unit converts to double bed

Bed

 Queen-size bed with suspension, ventilation and comfortable mattress in the rear on pedestal

 Size: 60" x 80" ( 1524 mm x 2032 mm )

Sanitary room

 Sealed fiberglass door to isolate bathroom from living area

 SeaLand ceramic toilet system

 Bath sink – SS w/extra faucet for filtered water, soap dish, towel hooks

 Shower – full size w/adjustable height head, 2X soap/shampoo dishes, SS overhead drying bar

 Medicine cabinet and storage under sink

Kitchen

 Countertop with integrated SS sink

 Collapsible counter top leaf to left of oven/range

 Single handle faucet for warm and cold water, separate faucet for filtered water

 SS soap dispenser, soap dish, towel hooks

 Force10 LPG 3-flame range/oven

 Sanyo 1.2 cubic foot SS microwave oven

 Kitchen cabinets with locking drawers on ball bearings

 Built-in drawer organizers

 Overhead cupboards

 Refrigeration – 2 X 113 liter Kissman w/small freezers, 45 qt freezer and ice maker in luggage compartment

Storage

 Inside storage space in the seating area, kitchen and over bed

 Wardrobe for hanging clothes, pull-out storage boxes

 Large outside storage compartment under the bed pedestal

 Exterior storage - 2 X SS 24” X 24” X 24” 1 X SS 24” X 24” X 48” tool/utility boxes

Workmanship

 All furniture is built to the highest cabinet making standard made of wood core plywood using heavy duty locks and hinges

 Finishes may be specified by customer

Lay out

 Design and color of floor, walls and ceiling may be chosen by customer

 Walls and ceiling are painted with multiple coats

 Upholstery made of fabric, leather or ALCANTARA

Technical equipment

Electrical equipment

 Solar panels – 3 X 123w Sharp

 Control panel for power management and monitoring of liquid levels

 Battery main switch, safety cut-out, residual current breaker

 DC power supplied by (4) AGM batteries bank, automatic regulated alternator and AC automatic I-U charger with cell temperature sensing for shore power hook-up

 Battery capacity: 12V 840Ah

 Shore charge rate: 14V 120A

 Inverter – Xantrex Prosine 12V / 115V, max output 3.0 kW

 Power plugs for 12V DC and 115V AC

Audio-visual system

 Alpine CDA-9857, CD changer, AM FM, XM sat radio, Ipod

 Sharp 21” LCD HDTV/DVD players at bed and dining area

 Brackets and wiring for outside speakers

Lighting

 Low voltage XELOGEN ceiling lights over the table, kitchen, bed and shower

 Lights for outside storage compartment

 Reading lights in bed and seating area

Water supply

 112 gallons ( 425 liters ) freeze-proof drinking water tanks

 8 gallons ( 22 liters ) hot water heat-exchanger

 15 gallons ( 60 liters ) waste water tank

 25 gallons (100 liters) gray water tank

 All plumbing is insulated to prevent freezing

 Outside shower at rear luggage compartment

 Water filtration system

LPG supply

 2 x 30 lb. cylinders in sealed compartment

 Quick connect for barbecue at rear luggage compartment

Heating, ventilation and A/C systems

 Webasto diesel powered warm water central heating ( 5 kW )

 Radiant heaters at shower, dining area, and coil under bed

 Anti-frost system

 2 X 13,500 BTU Penguin A/C roof units

 Maxxfan units above sink and in bath

Alarm system and emergency equipment

 Fire, smoke and carbon monoxide detector/alarm

 Mag-lite flashlight/charger at door

 SS fire extinguisher at door

Options

 BGAN global communications system (voice and data)

 Custom rear rack for inflatable boat, motorcycle, bicycles

 Portable (Spectra “Aquifer”) 6 gph reverse osmosis unit

 Expedition grade first aid kit

 Self extrication kit

 Chassis/motor-specific expedition replacement parts kit

 Generator expedition replacement parts kit

 Emergency outside (DragonMax) lighting

 International water connectors/adaptors and hoses kit

 International electrical adaptors kit

 International propane adaptors kit

 Air fittings and hoses kit

:thumbsupanim - Terry

Link to comment
Share on other sites

Too funny Chris! The boss told me to buck-up. :baaasmiley: She says I'll be darn lucky to get this set up! :inocent:

post-22152-127550420517_thumb.jpg

:yuk-yuk: - Terry

My power ball reality dream rig. :) I did win $17 once.

post-861-127549701066_thumb.jpg

Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

  • Recently Browsing   0 members

    • No registered users viewing this page.
×
×
  • Create New...